Effects of anaerobic digestion and aerobic treatment on the reduction of gaseous emissions from dairy manure storages

Authors

  • Ruihong Zhang PhD, Prof. Former President of AOC. University of California, Davis
  • Jeffery A. McGarvey Western Regional Research Center USDA
  • Yanguo Ma Biological and Agricultural Engineering Department, University of California
  • Frank M. Mitloehner Department of Animal Science, University of California

Keywords:

anaerobic digestion, aerobic treatment, methane, volatile organic compounds, dairy manure

Abstract

Effects of anaerobic digestion and aerobic treatment on the reduction of gaseous emissions from dairy manure storages were evaluated in this study. Screened dairy manure containing 3.5% volatile solids (VS) was either anaerobically digested or aerobically treated prior to storage in air-tight vessels. Anaerobic digestion was carried out using a mesophilic anaerobic sequencing batch reactor operated at a hydraulic retention time of 20 days and an organic loading rate (OLR) of 1 gVS/L/day. Aerobic treatment was achieved using an aerobic reactor operated at a hydraulic retention time (HRT) of 10 days and an OLR of 2 gVS/(L·d). The treated manure was put into the storage on a daily basis for a period of 180 days. All the gases produced during this period were captured and analyzed for methane, carbon dioxide and volatile organic compounds (VOCs). Untreated manure was stored and analyzed in the same way as the treated manure and used as a control for comparison. The results show that low amounts of gases were produced during the first 84 days of storage in both treated and untreated manure, but increased significantly after this time point. The generally expected positive impacts of anaerobic and aerobic treatment on the reductions of methane and VOCs were
confirmed in this study. However, the effects of anaerobic and aerobic treatment varied over the time of storage, especially for VOCs. The results of this study indicate that to achieve significant reductions in VOC emission the storage time of anaerobic digester or aerobic reactor effluent should be limited to no more than 100 days.


Key words: anaerobic digestion, aerobic treatment, methane, volatile organic compounds, dairy manure
DOI: 10.3965/j.issn.1934-6344.2008.02.015-020
Citation: Ruihong Zhang, Jeffery A. McGarvey, Yanguo Ma, Frank M. Mitloehner. Effects of anaerobic digestion and
aerobic treatment on the reduction of gaseous emissions from dairy manure storages. Int J Agric & Biol Eng. 2008; 1(2):
15

Author Biography

Ruihong Zhang, PhD, Prof. Former President of AOC. University of California, Davis

Ruihong Zhang,

PhD, Prof. Former President of AOC. University of California, Davis, CA, USA. Email: rhzhang@ucdavis.edu

Downloads

Published

2008-12-19

How to Cite

Zhang, R., McGarvey, J. A., Ma, Y., & Mitloehner, F. M. (2008). Effects of anaerobic digestion and aerobic treatment on the reduction of gaseous emissions from dairy manure storages. International Journal of Agricultural and Biological Engineering, 1(2), 15–20. Retrieved from https://ijabe.migration.pkpps03.publicknowledgeproject.org/index.php/ijabe/article/view/47

Issue

Vol. 1 No. 2 (2008): IJABE

Section

Structures and Bio-environmental Engineering

License

IJABE is an international peer reviewed open access journal, adopting Creative Commons Copyright Notices as follows.


Authors who publish with this journal agree to the following terms:


  1. Authors retain copyright and grant the journal right of first publication with the work simultaneously licensed under a Creative Commons Attribution License that allows others to share the work with an acknowledgement of the work's authorship and initial publication in this journal.

  2. Authors are able to enter into separate, additional contractual arrangements for the non-exclusive distribution of the journal's published version of the work (e.g., post it to an institutional repository or publish it in a book), with an acknowledgement of its initial publication in this journal.

  3. Authors are permitted and encouraged to post their work online (e.g., in institutional repositories or on their website) prior to and during the submission process, as it can lead to productive exchanges, as well as earlier and greater citation of published work (See The Effect of Open Access).